VNH5019A-E 반도체 회로 부품 판매점
Automotive fully integrated H-bridge motor driver
|
|
 STMicroelectronics |
VNH5019A-E
Automotive fully integrated
H-bridge motor driver
Features
Type
VNH5019A-E
RDS(on)
18 mΩ typ
(per leg)
Iout
30 A
Vccmax
41 V
■ ECOPACK®: lead free and RoHS compliant
■ Automotive Grade: compliance with AEC
guidelines
■ Output current: 30 A
■ 3 V CMOS compatible inputs
■ Undervoltage and overvoltage shutdown
■ High-side and low-side thermal shutdown
■ Cross-conduction protection
■ Current limitation
■ Very low standby power consumption
■ PWM operation up to 20 khz
■ Protection against:
– Loss of ground and loss of VCC
■ Current sense output proportional to motor
current
■ Charge pump output for reverse polarity
protection
■ Output protected against short to ground and
short to VCC
Description
The VHN5019A-E is a full bridge motor driver
intended for a wide range of automotive
applications. The device incorporates a dual
monolithic high-side drivers and two low-side
switches. The high-side driver switch is designed
using STMicroelectronics’ well known and proven
proprietary VIPower® M0 technology that allows
to efficiently integrate on the same die a true
MultiPowerSO-30™
Power MOSFET with an intelligent
signal/protection circuit.
The three dice are assembled in
MultiPowerSO-30 package on electrically isolated
lead-frames. This package, specifically designed
for the harsh automotive environment offers
improved thermal performance thanks to exposed
die pads. The input signals INA and INB can
directly interface to the microcontroller to select
the motor direction and the brake condition.
The DIAGA/ENA or DIAGB/ENB, when connected
to an external pull-up resistor, enable one leg of
the bridge. They also provide a feedback digital
diagnostic signal. The CS pin allows to monitor
the motor current by delivering a current
proportional to its value when CS_DIS pin is
driven low or left open. The PWM, up to 20 KHz,
lets us to control the speed of the motor in all
possible conditions. In all cases, a low-level state
on the PWM pin turns-off both the LSA and LSB
switches. When PWM rises to a high-level, LSA or
LSB turn-on again depending on the input pin
state.
Output current limitation and thermal shutdown
protects the concerned high-side in short to
ground condition.
The short to battery condition is revealed by the
overload detector or by thermal shutdown that
latches off the relevant low-side.
Active VCC pin voltage clamp protects the device
against low energy spikes in all configurations for
the motor.
CP pin provides the necessary gate drive for an
external n-channel PowerMOS used for reverse
polarity protection.
September 2013
Doc ID 15701 Rev 9
1/37
www.st.com
1
Contents
Contents
VNH5019A-E
1 Block diagram and pin description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
2 Electrical specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2.1 Absolute maximum ratings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2.2 Thermal data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
2.3 Electrical characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
2.4 Waveforms and truth table . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
2.5 Reverse battery protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
3 Package and PCB thermal data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
3.1 MultiPowerSO-30 thermal data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
3.1.1
Thermal calculation in clockwise and anti-clockwise operation in
steady-state mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
3.1.2 Thermal calculation in transient mode . . . . . . . . . . . . . . . . . . . . . . . . . . 27
4 Package and packing information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
4.1 ECOPACK® . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
4.2 MultiPowerSO-30 mechanical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
4.3 MultiPowerSO-30 suggested land pattern . . . . . . . . . . . . . . . . . . . . . . . . 32
4.4 MultiPowerSO-30 packing information . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
5 Order codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
6 Revision history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
2/37 Doc ID 15701 Rev 9
|
PDF 파일 내의 페이지 : 총 30 페이지
제조업체: STMicroelectronics
( stm )
VNH5019A-E driver
데이터시트 다운로드 :
[ VNH5019A-E.PDF ]
[ VNH5019A-E 다른 제조사 검색 ]
국내 전력반도체 판매점
상호 : 아이지 인터내셔날
전화번호 : 051-319-2877
[ 홈페이지 ]
IGBT, TR 모듈, SCR, 다이오드모듈, 각종 전력 휴즈
( IYXS, Powerex, Toshiba, Fuji, Bussmann, Eaton )
전력반도체 문의 : 010-3582-2743
